PrimeLock Rust Primer SDS

Safety Data Sheet

I. IDENTIFICATION

  • PRODUCT IDENTIFICATION
  • PrimeLock Rust Primer
  • Packaging: pails
  • CAS Number: n/a
  • DATE UPDATED: Thursday, May 10, 2018
  • EMERGENCY TELEPHONE NUMBER: INFOTRAC: 800-535-5053
COMPANY INFORMATION

II.  HAZARDS IDENTIFICATION

Classification of the substance or mixture

Skin Irrit. 2;H315: Causes skin irritation.

Eye Irrit. 2;H319: Causes serious eye irrtation.

Skin Sens. 1;H317: May cause an allergic skin reaction.

Label elements

Using the Toxicity Data listed in section 11 and 12 the product is labeled as follows.

Hazard Pictograms
  • Harmful
    Harmful

H315 Causes skin irritation.

H317 May cause an allergic skin reaction.

H319 Causes serious eye irritation.

[Prevention]:

P261 Avoid breathing dust / fume / gas / mist / vapors / spray.

P264 Wash thoroughly after handling.

P272 Contaminated work clothing should not be allowed out of the workplace.

P273 Avoid release to the environment.

P280 Wear protective gloves / eye protection / face protection.

[Response]:

P302+352 IF ON SKIN: Wash with plenty of soap and water.

P305+351+338 IF IN EYES: Rinse continuously with water for several minutes. Remove contact lenses if present and easy to do - continue rinsing.

P313 Get medical advice / attention.

P321 Specific treatment (see information on this label).

P333+313 If skin irritation or a rash occurs: Get medical advice / attention.

P337+313 If eye irritation persists: Get medical advice / attention.

P362 Take off contaminated clothing and wash before reuse.

P363 Wash contaminated clothing before reuse.

P391 Collect spillage.

[Storage]:

No GHS storage statements

[Disposal]:

P501 Dispose of contents / container in accordance with local / national regulations.

III.  COMPOSITIONS / INFORMATION ON INGREDIENTS

This product contains the following substances that present a hazard within the meaning of the relevant State and Federal Hazardous Substances regulations.

Ingredient/Chemical Designations
Weight %
GHS Classification
Notes
Zinc phosphate

CAS Number: 0007779-90-0

10 - 25
Aquatic Acute 1;H400

Aquatic Chronic 1;H410

[1]
2-N-octyl-4-isothiazoline-3-one
CAS Number: 0026530-20-1
0.10 - 1.0
Acute Tox. 3;H331
Acute Tox. 3;H311
Acute Tox. 4;H302
Skin Corr. 1B;H314
Skin Sens. 1;H317 (@>0.05%)
Aquatic Acute 1;H400
Aquatic Chronic 1;H410

[1]

In accordance with paragraph (i) of §1910.1200, the specific chemical identity and/or exact percentage (concentration) of composition has been withheld as a trade secret.

[1] Substance classified with a health or environmental hazard.
*The full texts of the phrases are shown in Section 16.

IV.  FIRST AID MEASURES

  • Description of first aid measures
  • General: In all cases of doubt, or when symptoms persist, seek medical attention. Never give anything by mouth to an unconscious person.
  • Inhalation: Remove to fresh air, keep patient warm and at rest. If breathing is irregular or stopped, give artificial respiration. If unconscious place in the recovery position and obtain immediate medical attention. Give nothing by mouth.
  • Eyes:  Irrigate copiously with clean water for at least 15 minutes, holding the eyelids apart and seek medical attention.
  • Skin:  Remove contaminated clothing. Wash skin thoroughly with soap and water or use a recognized skin cleanser.
  • Ingestion: If swallowed give two glasses of water to drink. Do not induce vomiting. Get medical attention immediately. Never give anything by mouth to an unconscious person.
  • Most important symptoms and effects, both acute and delayed
  • Overview   Effects of Overexposure:
  • Inhalation: Spray mist in poorly ventilated areas can cause headache, nausea and irritation of the nose, throat, & lungs. 
  • Eyes: Direct contact may cause irritation.
  • Skin: May cause moderate skin irritation with repeated contact.
  • See section 2 for further details.
  • Eyes: Causes serious eye irritation.
  • Skin:  May cause an allergic skin reaction. Causes skin irritation.

V.  FIRE-FIGHTING MEASURES 

  • Extinguishing media:  Water, carbon dioxide, foam or dry powder. 
  • Special hazards arising from the substance or mixture:  Hazardous decomposition: Acrylic monomersAvoid breathing dust / fume / gas / mist / vapors / spray.
  • Advice for fire-fighters:  Wear SCBA and full protective gear when entering a confined or enclosed space to protect from normal combustion products and/or oxygen deficiency. 
  • ERG Guide No.:   ----

VI.  ACCIDENTIAL RELEASE MEASURES

  • Personal precautions, protective equipment and emergency procedures:   Put on appropriate personal protective equipment (see section 8).
  • Environmental precautions:  Do not allow spills to enter drains or waterways.Use good personal hygiene practices. Wash hands before eating, drinking, smoking or using toilet. Promptly remove soiled clothing and wash thoroughly before reuse.
  • Methods and material for containment and cleaning up: Keep spectators away as the floor may be slippery. Use care to avoid falling. Keep spills out of municipal sewers and open bodies of water. Dike and contain spill with inert material such as dry sand or earth. Transfer liquid material to a suitable container for recovery or disposal.

VII.  HANDLING ADN STORAGE

  • Precautions for safe handling:  Keep from freezing.See section 2 for further details. - [Prevention]:
  • Conditions for safe storage, including any incompatibilities: Handle containers carefully to prevent damage and spillage.Incompatible materials: No known incompatible materials for this product.Recommended storage range is 45 - 90°F. Keep container tightly closed.See section 2 for further details. - [Storage]:
  • Specific end use(s): No data available.

VIII.  EXPOSURE CONTROLS AND PERSONAL PROTECTION

  • Control parameters Exposure 
  • Exposure controls 
  • Respiratory:  If workers are exposed to concentrations above the exposure limit they must use the appropriate, certified respirators.
  • Eyes:  Chemical splash goggles (ANSI Z-87.1 or approved equivalent)
  • Skin: Chemical impervious gloves required.
  • Engineering Controls:  Provide adequate ventilation. Where reasonably practicable this should be achieved by the use of local exhaust ventilation and good general extraction. If these are not sufficient to maintain concentrations of particulates and any vapor below occupational exposure limits suitable respiratory protection must be worn. 
  • Other Work Practices: Use good personal hygiene practices. Wash hands before eating, drinking, smoking or using toilet. Promptly remove soiled clothing and wash thoroughly before reuse.See section 2 for further details. - [Prevention]:

IX.  PHYSICAL AND CHEMICAL PROPERTIES

Appearance Milky white, gray or black Liquid Not Specified
Odor Not Specified
Odor threshold Not Measured
pH Not available
Melting point / freezing point
0°C (32°F)
Initial boiling point and boiling range 100°C (212°F)
Flash Point Non-combustible
Evaporation rate (Ether = 1) Less than 1 (n-BuAc = 1)
Flammability (solid, gas) Not Applicable
Upper/lower flammability or explosive limits Lower Explosive Limit: Not applicable
Upper Explosive Limit: Not applicable
Vapor pressure (Pa) Greater than 1
Vapor Density Not available
Specific Gravity Not available
Solubility in Wate Dispersible
Partition coefficient n-octanol/water (Log Kow) Not Measured
Auto-ignition temperature Not applicable
Decomposition temperature Not available
Viscosity (cSt) 500 - 1100 cps
VOC Content Less than 35 g/liter
Density 8.8 - 9.2 pounds per gallon
% Volatile 66 - 70% (by volume)

Other information
No other relevant information.

X.  STABILITY AND REACTIVITY

  • Reactivity:  Hazardous Polymerization will not occur.
  • Chemical stability:  Stable under normal circumstances. 
  • Possibility of hazardous reactions: No data available.
  • Conditions to avoid: No data available.
  • Incompatible materials: No known incompatible materials for this product. 
  • Hazardous decomposition products: Acrylic monomers

XI.  TOXICOLOGICAL INFORMATION

Acute toxicity

IngredientOral LD50, mg/kgSkin LD50, mg/kgInhalation Vapor LC50, mg/L/4hrInhalation Dust/Mist LC50, mg/L/4hrInhalation Gas LC50, ppm
Zinc phosphate - (7779-90-0)> 5,000.00, Rat - Category: NANo data availableNo data availableNo data availableNo data available
2-N-octyl-4-isothiazoline-3-one - (26530-20-1)550.00, Rat - Category: 4690.00, Rabbit - Category: 3No data available0.27, Rat - Category: 2No data available

Note: When no route specific LD50 data is available for an acute toxin, the converted acute toxicity point estimate was used in the calculation of the product's ATE (Acute Toxicity Estimate).

Carcinogen Data

XII.  ECOLOGICAL INFORMATION

Toxicity

Very toxic to aquatic life with long lasting effects.
No additional information provided for this product. See Section 3 for chemical specific data.

Aquatic Ecotoxicity

Ingredient96 hr LC50 fish, mg/l48 hr EC50 crustacea, mg/lErC50 algae, mg/l
Zinc phosphate - (7779-90-0)0.09, Oncorhynchus mykiss0.04, Daphnia magna0.136 (72 hr), Selenastrum capricornutum
2-N-octyl-4-isothiazoline-3-one - (26530-20-1)0.0555, Oncorhynchus mykiss0.18, Daphnia magna0.084 (72 hr), Scenedesmus subspicatus
  • Persistence and degradability: There is no data available on the preparation itself.
  • Bioaccumulative potential: Not Measured
  • Mobility in soil:  No data available.
  • Results of PBT and vPvB assessment: This product contains no PBT/vPvB chemicals.
  • Other adverse effects:  No data available.

XIII.  DISPOSAL CONSIDERATIONS

Waste treatment methods
Observe all federal, state and local regulations when disposing of this substance.

XIV. TRANSPORT INFORMATION  

DOT (Domestic Surface Transportation)IMO / IMDG (Ocean TransportationICAO/IATA
UN numberNot ApplicableNot RegulatedNot Regulated
UN proper shipping nameNot RegulatedNot RegulatedNot Regulated
Transport hazard class(es)DOT Hazard Class: Not ApplicableIMDG: Not ApplicableAir Class: Not Applicable
Sub Class: Not Applicable
Packing groupNot ApplicableNot ApplicableNot Applicable
Environmental hazards
IMDGMarine Pollutant: Yes (Zinc phosphate)
Special precautions for userNo further information

XV. REGULATORY INFORMATION

  • Regulatory Overview:  The regulatory data in Section 15 is not intended to be all-inclusive, only selected regulations are represented.​
  • Toxic Substance Control Act ( TSCA):  All components of this material are either listed or exempt from listing on the TSCA Inventory.
  • WHMIS Classification: D2B
  • US EPA Tier II Hazards: Fire: No , Sudden Release of Pressure: No, Reactive: No, Immediate (Acute): Yes, Delayed (Chronic): No
  • EPCRA 311/312 Chemicals and RQs:  To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
  • EPCRA 302 Extremely Hazardous:  To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
  • EPCRA 313 Toxic Chemicals:  Zinc phosphate
  • Proposition 65 - Carcinogens (>0.0%):  Regulatory dddddTitanium dioxide
  • Proposition 65 - Developmental Toxins (>0.0%): To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
  • Proposition 65 - Female Repro Toxins (>0.0%):  To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
  • Proposition 65 - Male Repro Toxins (>0.0%):  To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
  • New Jersey RTK Substances (>1%) :  To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
  • Pennsylvania RTK Substances (>1%) : To the best of our knowledge, there are no chemicals at levels which require reporting under this statute. 

XVI.  OTHER INFORMATION

This is the first version in the GHS SDS format. Listings of changes from previous versions in other formats are not applicable.

The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text.