PrimeLock MultiSurface SDS

Safety Data Sheet

I. IDENTIFICATION

PRODUCT IDENTIFICATION
PrimeLock MultiSurface
Packaging:
CAS Number: n/a
DATE UPDATED
Thursday, May 10, 2018
EMERGENCY TELEPHONE NUMBER

800-535-5053

SUPPLIER INFORMATION

II. HAZARDS(S) IDENTIFICATION

  • Classification of the substance or mixture
  • Skin Irrit. 2;H315 Causes skin irritation.
  • Eye Irrit. 2;H319 Causes serious eye irritation
  • Skin Sens. 1;H317 May cause an allergic skin reaction.
  • Muta. 1B;H340 May cause genetic defects.
  • Carc. 1A;H350 May cause cancer.
  • Repr. 2;H361D Suspected of damaging the unborn child.
  • STOT RE 2;H373 May cause damage to organs through prolonged or repeated exposure. Specific Target Organs: (Not Available)
  • Label elements
  • Using the Toxicity Data listed in section 11 and 12 the product is labeled as follows.
Hazard Pictograms
  • Harmful
    Harmful
  • Health Hazard
    Health Hazard
  • H315 Causes skin irritation
  • H317 May cause an allergic skin reaction
  • H319 Causes serious eye irritation.
  • H340 May cause genetic defects.
  • H350 May cause cancer.
  • H361d Suspected of damaging the unborn child.
  • H373 May cause damage to organs through prolonged or repeated exposure.
  • H411 Toxic to aquatic life with long lasting effects.
  • [Prevention]:
  • P201 Obtain special instructions before use.
  • P202 Do not handle until all safety precautions have been read and understood.
  • P261 Avoid breathing dust / fume / gas / mist / vapors / spray.
  • P262 Do not get in eyes, on skin, or on clothing.
  • P264 Wash thoroughly after handling.
  • P272 Contaminated work clothing should not be allowed out of the workplace.
  • P273 Avoid release to the environment.
  • P280 Wear protective gloves / eye protection / face protection.
  • [Response]:
  • P301+310 IF SWALLOWED: Immediately call a POISON CENTER or doctor / physician.
  • P302+352 IF ON SKIN: Wash with plenty of soap and water.
  • P305+351+338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses if present and easy to do - continue rinsing.
  • P308+313 IF exposed or concerned: Get medical advice / attention.
  • P314 Get Medical advice / attention if you feel unwell.
  • P321 Specific treatment (see information on this label).
  • P331 Do NOT induce vomiting.
  • P333+313 If skin irritation or a rash occurs: Get medical advice / attention
  • P337+313 If eye irritation persists: Get medical advice / attention.
  • P362 Take off contaminated clothing and wash before reuse.
  • P363 Wash contaminated clothing before reuse.
  • P391 Collect spillage.
  • [Storage]:
  • P405 Store locked up.
  • [Disposal]:
  • P501 Dispose of contents / container in accordance with local / national regulations.

III. COMPOSITION / INFORMATION ON INGREDIENTS

This product contains the following substances that present a hazard within the meaning of the relevant State and Federal Hazardous Substances regulations.

Ingredient/Chemical DesignationsWeight %GHS Classification Notes
Aliphatic Hydrocarbon CAS Number: 0064742-49-025 - 50Asp. Tox. 1;H304[1]
Acetone CAS Number: 0000067-64-110 - 25Flam. Liq. 2;H225 Eye Irrit. 2;H319 STOT SE 3;H336[1][2]
Styrene-Butadiene polymer CAS Number: 0009003-55-810 - 25Skin Sens. 1;H317[1]
Toluene CAS Number: 0000108-88-31.0-10Flam. Liq. 2;H225 Repr. 2;H361d Asp. Tox. 1;H304 STOT RE 2;H373 Skin Irrit. 2;H315 STOT SE 3;H336[1][2]
Zinc oxide CAS Number: 0001314-13-21.0 - 10Aquatic Acute 1;H400 Aquatic Chronic 1;H410[1][2]
Xylene CAS Number: 0001330-20-71.0 - 10Flam. Liq. 3;H226 Acute Tox. 4;H332 Acute Tox. 4;H312 Skin Irrit. 2;H315[1][2]
Distillates (petroleum), hydrotreated heavy naphthenic; Baseoil-unspecified CAS Number: 0064742-52-51.0 - 10Asp. Tox. 1;H304 [1]
Cyclohexane CAS Number: 0000110-82-71.0 - 10Flam. Liq. 2;H225 Asp. Tox. 1;H304 Skin Irrit. 2;H315 STOT SE 3;H336 Aquatic Acute 1;H400 Aquatic Chronic 1;H410[1][2]
Octane CAS Number: 0000111-65-91.0 - 10Flam. Liq. 2;H225 Asp. Tox. 1;H304 Skin Irrit. 2;H315 STOT SE 3;H336 Aquatic Acute 1;H400 Aquatic Chronic 1;H410[1][2]
Heptane CAS Number: 0000142-82-51.0 - 10Flam. Liq. 2;H225 Asp. Tox. 1;H304 Skin Irrit. 2;H315 STOT SE 3;H336 Aquatic Acute 1;H400 Aquatic Chronic 1;H410[1][2]
Benzene CAS Number: 0000071-43-20.10 - 1.0Flam. Liq. 2;H225 Carc. 1A;H350 Muta. 1B;H340 STOT RE 1;H372 Asp. Tox. 1;H304 Eye Irrit. 2;H319 Skin Irrit. 2;H315[1][2]
2-N-octyl-4-isothiazoline-3-one CAS Number: 0026530-20-10.01 - 0.10Acute Tox. 3;H331 Acute Tox. 3;H311 Acute Tox. 4;H302 Skin Corr. 1B;H314 Skin Sens. 1;H317 (@>0.05%) Aquatic Acute 1;H400 Aquatic Chronic 1;H410[1]
  • In accordance with paragraph (i) of §1910.1200, the specific chemical identity and/or exact percentage (concentration) of composition has been withheld as a trade secret
  • [1] Substance classified with a health or environmental hazard.
  • [2] Substance with a workplace exposure limit.
  • *The full texts of the phrases are shown in Section 16.

IV. FIRST-AID MEASURES

  • General In all cases of doubt, or when symptoms persist, seek medical attention. Never give anything by mouth to an unconscious person.
  • Inhalation Remove to fresh air, keep patient warm and at rest. If breathing is irregular or stopped, give artificial respiration. If unconscious place in the recovery position and obtain immediate
  • Eyes Flush with water initially and remove contact lenses. Continue to flush eyes with large amounts of water for 15 minutes. Get medical attention immediately.
  • Skin Remove contaminated clothing and shoes/boots. Wash affected area with large amounts of soap and water. Get medical attention immediately
  • Ingestion If swallowed do not give anything to drink. Do not induce vomiting except under physician’s instruction. Get medical attention immediately. Never give anything by mouth to an unconscious person.
  • Most important symptoms and effects, both acute and delayed
  • Overview 
  • EFFECTS OF OVEREXPOSURE - EYE CONTACT: Liquid, aerosols and vapors of this product are irritating and can cause pain, tearing, reddening and swelling accompanied by a stinging sensation and/or a feeling like that of fine dust in the eyes
  • EFFECTS OF OVEREXPOSURE - SKIN CONTACT: Prolonged or repeated contact can result in defatting and drying of the skin which may result in skin irritation and dermatitis(rash).
  • EFFECTS OF OVEREXPOSURE - INHALATION: Harmful if inhaled. Headaches, dizziness, nausea, decreased blood pressure, changes in heart rate and cyanosis may result from over-exposure to vapor or skin exposure. Breathing saturated vapors for a few minutes may be fatal. Saturated vapors can be encountered in confined spaces and/or under conditions of poor ventilation. Prolonged inhalation may be harmful.
  • EFFECTS OF OVEREXPOSURE - INGESTION: This material may be harmful or fatal if swallowed.
  • EFFECTS OF OVEREXPOSURE - CHRONIC HAZARDS: Over exposure may cause lung damage.
  • Reproductive or genetic defect hazard. Exposure to solvent vapor concentrations from the component solvents in excess of the stated occupational exposure limits may result in adverse health effects such as mucous membrane and respiratory system irritation and adverse effects on the kidneys, liver and central nervous system. Symptoms include headache, nausea, dizziness, fatigue, muscular weakness, drowsiness and in extreme cases, loss of consciousness.
  • Repeated or prolonged contact with the preparation may cause removal of natural fat from the skin resulting in dryness, irritation and possible non-allergic contact dermatitis. Solvents may also be absorbed through the skin. Splashes of liquid in the eyes may cause irritation and soreness with possible reversible damage. See section 2 for more details
  • Eyes Causes serious eye irritation.
  • Skin May cause an allergic skin reaction. Causes skin irritation.

V. FIRE-FIGHTING MEASURES

  • Extinguishing media
  • Water, carbon dioxide, foam or dry powder.
  • Special hazards arising from the substance or mixture
  • Hazardous decomposition: Reaction with water can create CO2.
  • Avoid breathing dust / fume / gas / mist / vapors / spray.
  • Do not get in eyes, on skin, or on clothing.
  • Advice for fire-fighters
  • Do not mix with strong oxidizers such as liquid chlorine or concentrated oxygen.
  • Use water spray to cool non-involved containers.
  • Wear SCBA with full-face piece operating in a positive pressure demand mode and full protective gear.
  • ERG Guide No. 127

VI. ACCIDENTAL RELEASE MEASURES

  • Personal precautions, protective equipment and emergency procedures
  • Put on appropriate personal protective equipment (see section 8).
  • Environmental precautions
  • Do not allow spills to enter drains or waterways.
  • Use good personal hygiene practices. Wash hands before eating, drinking, smoking or using toilet. Promptly remove soiled clothing and wash thoroughly before reuse.
  • Methods and material for containment and cleaning up
  • Shut off ignition sources including electrical equipment and flames. Contain spilled material. Absorb spills with inert material such as vermiculite, dry sand or earth. Place in a closed container but do not seal. Ventilate area to remove vapors.

VII. HANDLING AND STORAGE

  • Precautions for safe handling
  • Avoid prolonged or repeated skin contact. Avoid breathing aerosols, spray mists, and heated vapors. Use only in well ventilated area. Use good personal and industrial hygiene practices. Keep container closed after each use.
  • See section 2 for further details. - [Prevention]:
  • Conditions for safe storage, including any incompatibilities
  • Handle containers carefully to prevent damage and spillage.
  • Incompatible materials: Contact with water will cause this product to cure. Incompatible with acids, bases, and oxidizers.
  • Recommended storage range is less than 90°F.
  • See section 2 for further details. - [Storage]:
  • Specific end use(s)
  • No data available.

VIII. EXPOSURE CONTROLS / PERSONAL PROTECTION

CAS No.IngredientSourceValue
0000067-64-1AcetoneOSHATWA 1000 ppm (2400 mg/m3 )STEL 2400 mg/m3
ACGIHTWA: 500 ppm STEL: 750 ppm
NIOSH250 ppm (590 mg/m3 ) TWA
0000071-43-2 BenzeneOSHA[1910.1028] TWA 1 ppm STEL 5 ppm
ACGIH TWA: 0.5 ppm STEL: 2.5 ppm Skin, A1, 1
NIOSHTWA 0.1 ppm ST 1 ppm
0000108-88-3TolueneOSHATWA 200 ppm C 300 ppm 500 ppm (10-minute maximum peak) STEL 150 ppm
ACGIH TWA: 20 ppm R
NIOSH TWA 100 ppm (375 mg/m3 ) ST 150 ppm (560 mg/m3 )
0000110-82-7 Cyclohexane OSHATWA 300 ppm (1050 mg/m3 )
ACGIH TWA: 100 ppm
NIOSHTWA 300 ppm (1050 mg/m3 )
0000111-65-9 OctaneOSHATWA 500 ppm (2350 mg/m3 )STEL 375 ppm
ACGIHTWA: 300 ppm
NIOSHTWA 75 ppm (350 mg/m3 ) C 385 ppm (1800 mg/m3 ) [15-minute]
0000142-82-5HeptaneOSHATWA 500 ppm (2000 mg/m3 )
ACGIH TWA: 400 ppm STEL: 500 ppm
NIOSHTWA 85 ppm (350 mg/m3 ) C 440 ppm (1800 mg/m3 ) [15-minute]
0001330-20-7XyleneOSHASTEL 150 ppm
ACGIH

Exposure controls

  • Respiratory If workers are exposed to concentrations above the exposure limit they must use the appropriate, certified respirators.
  • Eyes Chemical splash goggles (ANSI Z-87.1 or approved equivalent) and/or face shield. Have an eye wash station available.
  • Skin Chemical impervious gloves required.
  • Engineering Controls Provide adequate ventilation. Where reasonably practicable this should be achieved by the use of local exhaust ventilation and good general extraction. If these are not sufficient to maintain concentrations of particulates and any vapor below occupational exposure limits suitable respiratory protection must be worn.
  • Other Work Practices Use good personal hygiene practices. Wash hands before eating, drinking, smoking or using toilet. Promptly remove soiled clothing and wash thoroughly before reuse.
  • See section 2 for further details. - [Prevention]:

IX. PHYSICAL AND CHEMICAL PROPERTIES

  • Appearance Viscous Liquid
  • Odor Organic Solvent
  • Odor threshold Not determined
  • pH Not available
  • Melting point / freezing point Not available
  • Initial boiling point and boiling range 281 - 284°F
  • Flash Point 0°F
  • Evaporation rate (Ether = 1) Slower than ether
  • Flammability (solid, gas) Not Applicable
  • Upper/lower flammability or explosive limits: Lower Explosive Limit: 1%, Upper Explosive Limit: unknown
  • Vapor pressure (Pa) Not established
  • Vapor Density Not available
  • Specific Gravity Not available
  • Solubility in Water Nil, reacts with water
  • Partition coefficient n-octanol/water (Log Kow) Not Measured
  • Auto-ignition temperature Not established
  • Decomposition temperature Not available
  • Viscosity (cSt) 100 - 400 cps
  • VOC Content 452 g/liter
  • Density 6.8 - 7.2 pounds per gallon
  • % Volatile 65 - 69% (by volume)
  • Other information No other relevant information.

X. STABILITY AND REACTIVITY

  • Reactivity May polymerize
  • Chemical stability Stable under normal circumstances.
  • Possibility of hazardous reactions No data available.
  • Conditions to avoid Avoid contact with open flame, sparks or hot surfaces.
  • Incompatible materials Contact with water will cause this product to cure. Incompatible with acids, bases, and oxidizers
  • Hazardous decomposition products Reaction with water can create CO2.

XI. TOXICOLOGICAL INFORMATION

  • Acute toxicity
  • Exposure to solvent vapor concentrations from the component solvents in excess of the stated occupational exposure limits may result in adverse health effects such as mucous membrane and respiratory system irritation and adverse effects on the kidneys, liver and central nervous system. Symptoms include headache, nausea, dizziness, fatigue, muscular weakness, drowsiness and in extreme cases, loss of consciousness.
  • Repeated or prolonged contact with the preparation may cause removal of natural fat from the skin resulting in dryness, irritation and possible non-allergic contact dermatitis. Solvents may also be absorbed through the skin. Splashes of liquid in the eyes may cause irritation and soreness with possible reversible damage.
  • 2-butoxyethanol and its acetate are readily absorbed through the skin and will cause harmful effects on the blood.
Ingredient Oral LD50, mg/kgSkin LD50, mg/kgInhalation Vapor LC50, mg/L/4hrInhalation Dust/Mist LC50, mg/L/4hrInhalation Gas LC50, ppm
Aliphatic Hydrocarbon - (64742-49-0)5,000.00, Rat - Category: 53,160.00, Rabbit - Category: 5No data availableNo data availableNo data available
Acetone - (67-64-1)5,800.00, Rat - Category: NA7,426.00, Guinea Pig - Category: NA76.00, Rat- Category: NA50.10, Rat - Category: NANo data available
Toluene - (108-88-3) 636.00, Rat - Category: 48,400.00, Rabbit - Category: NANo data availableNo data availableNo data available
Zinc oxide - (1314-13-2)5,000.00, Rat - Category: 5No data availableNo data available2.50, Mouse - Category: 4No data available
Xylene - (1330-20-7)4,299.00, Rat - Category: 51,548.00, Rabbit - Category: 4No data available20.00, Rat - Category: NA5,000.00, Rat - Category: 4
Distillates (petroleum), hydrotreated heavy naphthenic; Baseoil-unspecified - (64742-52-5)> 5,000.00, Rat - Category: NANo data availableNo data available5.70, Rat - Category: NANo data available
Cyclohexane - (110-82-7)12,705.00, Rat - Category: NA2,000.00, Rabbit - Category: 4No data availableNo data availableNo data available
Heptane - (142-82-5)17,000.00, Rat - Category: NA3,000.00, Rabbit - Category: 5103.00, Rat - Category: NANo data availableNo data available
Benzene - (71-43-2)2,990.00, Rat - Category: 58,263.00, Rat - Category: 544.70, Rat - Category: NANo data availableNo data available
2-N-octyl-4-isothiazoline-3-one - (26530-20-1)550.00, Rat - Category: 4690.00, Rabbit - Category: 3No data available0.27, Rat - Category: 2No data available
  • Note: When no route specific LD50 data is available for an acute toxin, the converted acute toxicity point estimate was used in the calculation of the product's ATE (Acute Toxicity Estimate).
  • Carcinogen Data
CAS NoIngredientSourceValue
0000071-43-2BenzeneOSHASelect Carcinogen: Yes
IARCGroup 1: Yes
0000108-88-3TolueneIARCGroup 3: Yes
0001330-20-7 XyleneIARCGroup 3: Yes
0009003-55-8Styrene-Butadiene polymerIARCGroup 3: Yes

XII. ECOLOGICAL INFORMATION

  • Toxicity
  • Toxic to aquatic life with long lasting effects.
  • No additional information provided for this product. See Section 3 for chemical specific data.
  • Aquatic Ecotoxicity
Ingredient96 hr LC50 fish, mg/l48 hr EC50 crustacea, mg/ErC50 algae, mg/l
Aliphatic Hydrocarbon - (64742-49-0) Not Available2.60, Chaetogammarus marinusNot Available
Acetone - (67-64-1) 100.00, Pimephales promelas10.00, Daphnia magna20.565 (72 hr), Ulva pertusa
Toluene - (108-88-3) 5.80, Oncorhynchus mykiss19.60, Daphnia magnaNot Available
Zinc oxide - (1314-13-2)1.10, Oncorhynchus mykiss0.098, Daphnia magna0.042 (72 hr), Pseudokirchneriella subcapitata
Xylene - (1330-20-7)3.30, Oncorhynchus mykiss8.50, Palaemonetes pugio100.00 (72 hr), Chlorococcales
Distillates (petroleum), hydrotreated heavy naphthenic; Baseoil-unspecified - (64742-52-5)5,000.00, Oncorhynchus mykiss1,000.00, Daphnia magna1,000.00 (96 hr), Scenedesmus subspicatus
Cyclohexane - (110-82-7)8.20, Morone saxatilis3.78, Daphnia magna500.00 (72 hr), Scenedesmus subspicatus
Heptane - (142-82-5)375.00, Oreochromis mossambicus50.00, Daphnia magnaNot Available
Benzene - (71-43-2)5.90, Oncorhynchus mykiss9.20, Daphnia magna29.00 (72 hr), Pseudokirchneriella subcapitata
2-N-octyl-4-isothiazoline-3-one - (26530-20-1)0.0555, Oncorhynchus mykiss0.18, Daphnia magna0.084 (72 hr), Scenedesmus subspicatus
  • Persistence and degradability
  • There is no data available on the preparation itself.
  • Bioaccumulative potential
  • Not Measured
  • Mobility in soil
  • No data available.
  • Results of PBT and vPvB assessment
  • This product contains no PBT/vPvB chemicals.
  • Other adverse effects
  • No data available.

XIII. DISPOSAL CONSIDERATIONS

  • Waste treatment methods
  • Observe all federal, state and local regulations when disposing of this substance.

XIV. TRANSPORT INFORMATION

DOT (Domestic Surface Transportation)IMO / IMDG (Ocean Transportation)ICAO/IATA
UN numberUN1263UN1263 UN1263
UN proper shipping nameUN1263, Paint, 3, IIIPaintPaint
Transport hazard class(es)DOT Hazard Class: 3IMDG: 3 Sub Class: Not ApplicableAir Class: 3
Packing groupIIIIIIIII
Environmental hazards
IMDGMarine Pollutant: Yes ( Aliphatic Hydrocarbon )
Special precautions for user
No further information

XV. REGULATORY INFORMATION

  • Regulatory Overview The regulatory data in Section 15 is not intended to be all-inclusive, only selected regulations are represented.
  • Toxic Substance Control Act ( TSCA)
  • All components of this material are either listed or exempt from listing on the TSCA Inventory
  • WHMIS Classification D2A
  • US EPA Tier II Hazards 
  • Fire: No
  • Sudden Release of Pressure: No
  • Reactive: No
  • Immediate (Acute): Yes
  • Delayed (Chronic): Yes
  • EPCRA 311/312 Chemicals and RQs (lbs):
  • Acetone ( 5,000.00)
  • Cyclohexane ( 1,000.00)
  • Toluene ( 1,000.00)
  • Xylene ( 100.00)
  • EPCRA 302 Extremely Hazardous:
  • To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
  • EPCRA 313 Toxic Chemicals:
  • Benzene
  • Cyclohexane
  • Ethyl Benzene
  • Toluene
  • Xylene
  • Zinc oxide
  • Proposition 65 - Carcinogens (>0.0%):
  • Benzene
  • Ethyl Benzene
  • Titanium dioxide
  • Proposition 65 - Developmental Toxins (>0.0%):
  • Benzene
  • Toluene
  • Proposition 65 - Female Repro Toxins (>0.0%):
  • To the best of our knowledge, there are no chemicals at levels which require reporting under this statute
  • Proposition 65 - Male Repro Toxins (>0.0%):
  • Benzene
  • New Jersey RTK Substances (>1%):
  • Acetone
  • Cyclohexane
  • Heptane
  • Octane
  • Toluene
  • Xylene
  • Zinc oxide
  • Pennsylvania RTK Substances (>1%):
  • Acetone
  • Cyclohexane
  • Heptane
  • Octane
  • Toluene
  • Xylene
  • Zinc oxide

XVI. OTHER INFORMATION

This is the first version in the GHS SDS format. Listings of changes from previous versions in other formats are not applicable.

The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text.