PrimeLock Acrylic Primer SDS

Safety Data Sheet

I. IDENTIFICATION

PRODUCT IDENTIFICATION
PrimeLock Acrylic Primer
Packaging: buckets, drums
Thursday, May 10, 2018
EMERGENCY TELEPHONE NUMBER
800-535-5053
SUPPLIER INFORMATION

II. HAZARDS(S) IDENTIFICATION

Classification of the substance or mixture
  • Skin Irrit. 2;H315 - Causes skin irritation.
  • Eye Irrit. 2;H319 - Causes serious eye irritation.
  • Skin Sens. 1;H317 - May cause an allergic skin reaction.
Label elements
  • Using the Toxicity Data listed in section 11 and 12 the product is labeled as follows.
Hazard Pictograms
  • Harmful
    Harmful
  • H315 Causes skin irritation.
  • H317 May cause an allergic skin reaction.
  • H319 Causes serious eye irritation.
Prevention
  • P261 Avoid breathing dust / fume / gas / mist / vapors / spray.
  • P264 Wash thoroughly after handling.
  • P272 Contaminated work clothing should not be allowed out of the workplace.
  • P280 Wear protective gloves / eye protection / face protection.
Response
  • P302+352 IF ON SKIN: Wash with plenty of soap and water.
  • P305+351+338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses if present and easy to do - continue rinsing.
  • P313 Get medical advice / attention.
  • P321 Specific treatment (see information on this label).
  • P333+313 If skin irritation or a rash occurs: Get medical advice / attention.
  • P337+313 If eye irritation persists: Get medical advice / attention.
  • P362 Take off contaminated clothing and wash before reuse.
  • P363 Wash contaminated clothing before reuse.
Storage
  • No GHS storage statements
Disposal
  • P501 Dispose of contents / container in accordance with local / national regulations.

III. COMPOSITION / INFORMATION ON INGREDIENTS

This product contains the following substances that present a hazard within the meaning of the relevant State and Federal Hazardous Substances regulations.

Ingredient/Chemical DesignationsWeight %GHS ClassificationNotes
Titanium dioxide CAS Number: 0013463-67-71.0 - 10Not Classified[1][2]
2,2,4-trimethyl-1,3-pentanediol monoisobutyrate CAS Number: 0025265-77-41.0 - 10Not Classified[1]
2-N-octyl-4-isothiazoline-3-one CAS Number: 0026530-20-10.01 - 0.10Acute Tox. 3;H331 Acute Tox. 3;H311 Acute Tox. 4;H302 Skin Corr. 1B;H314 Skin Sens. 1;H317 (@>0.05%) Aquatic Acute 1;H400 Aquatic Chronic 1;H410[1]

In accordance with paragraph (i) of §1910.1200, the specific chemical identity and/or exact percentage (concentration) of composition has been withheld as a trade secret. [1] Substance classified with a health or environmental hazard. [2] Substance with a workplace exposure limit. *The full texts of the phrases are shown in Section 16.

IV. FIRST-AID MEASURES

Description of First Aid Measures
  • General: In all cases of doubt, or when symptoms persist, seek medical attention. Never give anything by mouth to an unconscious person.
  • Inhalation: Remove to fresh air, keep patient warm and at rest. If breathing is irregular or stopped, give artificial respiration. If unconscious place in the recovery position and obtain immediate medical attention. Give nothing by mouth.
  • Eyes: Irrigate copiously with clean water for at least 15 minutes, holding the eyelids apart and seek medical attention.
  • Skin: Remove contaminated clothing. Wash skin thoroughly with soap and water or use a recognized skin cleanser.
  • Ingestion: If swallowed give two glasses of water to drink. Do not induce vomiting. Get medical attention immediately. Never give anything by mouth to an unconscious person.
Effects of Overexposure
Inhalation: Spray mist in poorly ventilated areas can cause headache, nausea and irritation of the nose, throat, and lungs.
Eyes: Direct contact may cause irritation.
Skin: May cause moderate skin irritation with repeated contact.
See section 2 for further details.
Eyes
Causes serious eye irritation.
Skin
May cause an allergic skin reaction. Causes skin irritation.

V. FIRE-FIGHTING MEASURES

  • Extinguishing Media:  Water, carbon dioxide, foam or dry powder.
  • Special hazards arising from the substance or mixture:  Hazardous Decomposition: Acrylic monomers.Avoid breathing dust / fume / gas / mist / vapors / spray.
  • Advice for fire-fighters:  Wear SCBA and full protective gear when entering a confined or enclosed space to protect from normal combustion products and/or oxygen deficiency.

VI. ACCIDENTAL RELEASE MEASURES

Personal precautions, protective equipment and emergency procedures
Put on appropriate personal protective equipment (see section 8).
Environmental precautions
Do not allow spills to enter drains or waterways.
Use good personal hygiene practices. Wash hands before eating, drinking, smoking or using toilet. Promptly remove soiled clothing and wash thoroughly before reuse.
Methods and material for containment and cleaning up
Keep spectators away as the floor may be slippery. Use care to avoid falling. Keep spills out of municipal sewers and open bodies of water. Dike and contain spill with inert material such as dry sand or earth. Transfer liquid material to a suitable container for recovery or disposal. Scoop or shovel solid material into a suitable container for disposal.

VII. HANDLING AND STORAGE

Precautions for safe handling
Protect from freezing.
See section 2 for further details. - [Prevention]
Conditions for safe storage, including any incompatibilities
Handle containers carefully to prevent damage and spillage.
Incompatible materials: No known incompatible materials for this product.
Recommended storage range is 45-90°F.
Keep container tightly closed.
See section 2 for further details. - [Storage]
Specific end use(s)
No data available.

VIII. EXPOSURE CONTROLS / PERSONAL PROTECTION

  • Respiratory: If workers are exposed to concentrations above the exposure limit they must use theappropriate, certified respirators.
  • Eyes: Chemical splash goggles (ANSI Z-87.1 or approved equivalent).
  • Skin: Chemical impervious gloves required.
  • Engineering Controls: Provide adequate ventilation. Where reasonably practicable this should be achieved by the use of local exhaust ventilation and good general extraction. If these are not sufficient to maintain concentrations of particulates and any vapor below occupational exposure limits suitable respiratory protection must be worn.
  • Other Work Practices: Use good personal hygiene practices. Wash hands before eating, drinking, smoking or using toilet. Promptly remove soiled clothing and wash thoroughly before reuse.
  • See section 2 for further details. - [Prevention]

IX. PHYSICAL AND CHEMICAL PROPERTIES

AppearanceBlack or Gray Liquid
OdorSlight
Odor thresholdNot determined
pHNot available
Melting point / freezing point0°C (32°F)
Initial boiling point and boiling range100°C (212°F)
Flash PointNon-combustible
Evaporation rate (Ether = 1)Less than 1 (n-BuAc = 1)
Flammability (solid, gas)Not Applicable
Upper/lower flammability or explosive limitsLower Explosive Limit: Not applicable
Upper Explosive Limit: Not applicable
Vapor pressure (Pa)Greater than 1
Vapor DensityNot available
Specific GravityNot available
Solubility in WaterDispersible
Partition coefficient n-octanol/water (Log Kow)Not Measured
Auto-ignition temperatureNot applicable
Decomposition temperatureNot available
Viscosity (cSt)400 - 900 cps
VOC ContentLess than 35 g/Liter
Density8.3 - 8.9 pounds per gallon
% Volatile62 - 67% (by volume)

X. STABILITY AND REACTIVITY

  • Reactivity: Hazardous Polymerization will not occur.
  • Chemical Stability: Stable under normal circumstances.
  • Possibility of Hazardous Reactions: No data available.
  • Conditions to Avoid: No data available.
  • Incompatible Materials: No known incompatible materials for this product.
  • Hazardous Decomposition Products: Acrylic monomers

XI. TOXICOLOGICAL INFORMATION

Acute Toxicity
IngredientOral LD50 mg/kgSkin LD50 mg/kgInhalation Vapor LC50, mg/L/4hrInhalation Dust/Mist LC50, mg/L/4hrInhalation Gas LC50, ppm
Titanium dioxide (13463-67-7)10,000.00, Rat Category: NA10,000.00, Rabbit Category: NANo data available6.82, Rat Category: NANo data available
2,2,4-trimethyl-1,3-pentanediol monoisobutyrate (25265-77-4)3,200.00, Rat Category: 515,200.00, Rabbit Category: NANo data availableNo data availableNo data available
2-N-octyl-4-isothiazoline-3-one (26530-20-1)550.00, Rat Category: 4690.00, Rabbit Category: 3No data available0.27, Rat Category: 2No data available
Carcinogen Data
CAS No.IngredientSourceValue
0013463-67-7Titanium dioxideIARCGroup 2b: Yes

XII. ECOLOGICAL INFORMATION

Toxicity

Harmful to aquatic life.

Aquatic Ecotoxicity
Ingredient96 hr LC50 fish, mg/l48 hr EC50 crustacea, mg/lErC50 algae, mg/l
2-N-octyl-4-isothiazoline-3-one - (26530-20-1)0.0555, Oncorhynchus mykiss0.18, Daphnia magna0.084 (72 hr), Scenedesmus subspicatus
  • Persistence and Degradability: There is no data available on the preparation itself.
  • Bioaccumulative Potential: Not Measured
  • Mobility in soil: No data available.
  • Results of PBT and vPvB Assessment: This product contains no PBT/vPvB chemicals.
  • Other adverse effects: No data available.

XIII. DISPOSAL CONSIDERATIONS

  • Waste Treatment Methods: Observe all federal, state and local regulations when disposing of this substance.

XIV. TRANSPORT INFORMATION

DOT (Domestic Surface Transportation)IMO / IMDG (Ocean Transportation)ICAO/IATA
UN numberNot ApplicableNot RegulatedNot Regulated
UN proper shipping nameNot RegulatedNot RegulatedNot Regulated
Transport hazard class(es)DOT Hazard Class: Not ApplicableIMDG: Not Applicable Sub Class: Not ApplicableAir Class: Not Applicable
Packing groupNot ApplicableNot ApplicableNot Applicable
  • Environmental Hazards:
  • IMDG: Marine Pollutant: No
  • Special Precautions for User: No further information.

XV. REGULATORY INFORMATION

  • Regulatory Overview: The regulatory data in Section 15 is regulations are represented.
  • Toxic Substance Control Act ( TSCA): All components of this material are either listed or exempt from listing on the TSCA Inventory.
  • WHMIS Classification: D2B
US EPA Tier II Hazards
  • Fire: No
  • Sudden Release of Pressure: No
  • Reactive: No
  • Immediate (Acute): Yes
  • Delayed (Chronic): No
EPCRA 311/312 Chemicals and RQs:To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
EPCRA 302 Extremely Hazardous:To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
EPCRA 313 Toxic Chemicals:To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
Proposition 65 - Carcinogens (>0.0%):Titanium dioxide
Proposition 65 - Developmental Toxins (>0.0%):To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
Proposition 65 - Female Repro Toxins (>0.0%):To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
Proposition 65 - Male Repro Toxins (>0.0%):To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
New Jersey RTK Substances (>1%):Titanium dioxide
Pennsylvania RTK Substances (>1%):Titanium dioxide

XVI. OTHER INFORMATION

Most important symptoms and effects, both acute and delayed

The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text.